Hauling

Materials/Hauling

(Aggregate Hauling Division)

Mobile Concrete has a fleet of tractor trailers with which we haul our aggregates and cement to our plants. While the primary mission of this division is to keep materials at the required levels for the plants to operate, we do sell and will deliver some of the materials. Phelisha Dyal Williams supervises this division and is the point of contact for pricing information or to set up and schedule a delivery. You can reach her at (912) 427-2330.


Materials:

Sand:

We use #10 sand in concrete and have it "on the ground" at all of our plants. We also offer masonry sand and sand screenings.   

Rock:

The most common sizes of rock used in concrete are #57, #67 and #89 (the higher the number, the smaller the rock). We use granite or limestone in concrete and have a supply of some of each at our plants. We are a supplier of many other sizes of rocks (in both limestone and granite), including, but not limited to, #4's, riprap and gabc ("crush 'n run" basing).

Expansion Joints:

We are a distributor of metal expansion joints for Zambetti. Joints and stakes are usually available at our Jesup and Glennville plants. We will happily make what you need available at our other locations if you will call ahead of time. NOTE: Temporarily unavailable.

Washout:

Washout is refuge concrete that is returned to the plant. It is diluted with water and poured out in a holding area, then moved to a pile when dry. The most common use for washout is hole filler and surfacing on dirt drives/lanes. We try to keep the hard chunks to a minimum (and most chunks will easily break up), but we cannot guarantee it will be chunk free.

EZ Base™:

EZ Base™ (aka "poor man's concrete") is a by-product of combustion turbine electric generation. EZ Base™ is a cost effective alternative to gabc and can even be used for slab and driveway surface application if properly placed. We are a distributor of EZ Base™. Because it is hauled out of Jacksonville, EZ Base™ is only sold in complete truckload (24-25 ton) quantities.

The table below shows  the usual on-hand inventory by plant. Having a product on-hand means you can come in and pickup the material without calling ahead (unless you need a large quantity).

 

#10 Sand

#20 (Masonry)Sand

Sand Screening

#57 Lime

#57 Granite #67 Granite #89 Lime #89 Granite Expansion Joints Washout
Allenhurst

Y

N

N N Y Y Y Y N Y
Baxley Y N N N Y Y N Y N Y
Darien

Y

N

N Y N Y Y N N Y
Glennville

Y

Y

N Y Y Y Y Y N Y
Jesup Y N N Y N Y Y N N Y
Nahunta

Y

N

N Y N Y Y N N Y
 

Trucking/Hauling:

Our dump trucks are all semi's with trailers 30 to 40 feet in length. They can haul around 24 - 25 tons of material (about 18 cubic yards). As they are tractor trailers, we are somewhat limited in where we can deliver. If you wish to have us deliver rock or sand to you, please keep this in mind. The site will have be level and one that a tractor trailer can access; supporting close to 80,000 pounds, with room to swing and about 40 feet of overhead clearance (to allow the bed to rise when dumping). If your site will not accommodate our trucks, there are several hauling contractors in the area with straight tandem dump trucks.

Delivery:

We require a 10 ton minimum on materials we deliver. Delivery charges do apply and are usually charged on a per ton basis based on distance hauled. There is no minimum if you (or someone contracted by you) pick the material up.